California Grill Hot Dog Cart
- – 4 Burner double deck stainless steel grill w/grease tray
- – 2 Full size steam table w/controls (pans included)
- – 4 Sinks (wash, rinse, sanitize & hand washing)
- – Hot & cold pressurized water (four swivel faucets)
- – 20 Gallon fresh water tank
- – Insulated beverage bin w/drain (144 cans)
- – Compact refrigerator with adjustable shelves & interior light
- – 2 Propane tank enclosed compartment
The stainless steel grill on the California Grill hot dog cart is a double rack four independent burners with plenty of cooking space. The drip tray is below the barbecue and sufficient to hold grease for months, so you won’t have to clean it every day. Please know that people prefer grilled hot dogs and sausages rather than steamed.
The steam table on the California Grill hot dog cart is double and can accommodate various size pots and lids. You can use the steamer for the buns, chili and sauerkraut. You can also steam your hot dogs since the steam table has its own burner and shut off valve. The stainless steel pans and lids (2 spillage pans, 6 1/3 pans and 2 roll tops1) are included and easily removable for cleaning. These are NSF approved and listed.
SINKS (4 total)
The California Grill hot dog cart has three ware washing sinks with hot and cold water. Each ware washing sink is large enough to accommodate the largest utensil. Ware washing sinks are 12″ wide x 12″ long x 10″ deep. Each ware washing sink is equipped with a mixing swivel faucet capable of providing hot water at a minimum of 120 degrees Fahrenheit and cold water at 99 degrees Fahrenheit or less as required by law. The hand washing sink is separated from the ware washing sinks by a metal splashguard with a height of 8″.
The hand washing sink is 12″ wide x 9″ long x 10″ deep. The hand washing sink is equipped with a mixing swivel faucet capable of providing hot water at a minimum of 120 degrees Fahrenheit and cold water at 99 degrees Fahrenheit or less as required by law.
The water heater on the California Grill hot dog cart is capable of heating water to a minimum of 90 degrees Fahrenheit. It has a capacity of 4 gallons and it is interconnected to the potable water tanks.
The California Grill hot dog cart is equipped with an electrical water pump capable of delivering a minimum of 1 gallon per minute of hot and cold water.
POTABLE WATER TANK
The 4/5 gallon potable water tanks on the California Grill hot dog cart are sufficient in volume to fulfill the required 5 gallon minimum for hand washing and the 15 gallon for ware washing and food preparation.
All waste lines on the California Grill hot dog cart are connected to the wastewater tank with watertight seals. The wastewater tank has an air vent water flow to prevent potential flooding of the interior of the cart. The tank has a capacity of 30 gallons and it has a discharge valve to facilitate complete draining.
The beverages bin on the California Grill hot dog cart has its own drain and is insulated to maximize the life of the ice. It holds 144 cans. The lid is hinged and easily reachable for the customers to help themselves and for your to refill it.
The California Grill hot dog cart is equipped with an electrical refrigeration unit to store all potentially hazardous foods as required by California law.
There are two storage compartments on the California Grill hot dog cart. One is in the front and one is in the back. The storage compartment in the back is the perfect place to keep extra napkins, extra foil, paper bags, straws, tongs, spoons, etc. The storage compartment in the front under the steam table is the place to keep your fresh hot dog buns. Both compartments have a door with a safety latch.
The two 9 feet market umbrella on the California Grill hot dog cart could be green, navy blue and some other colors (your choice). The umbrella holders are at each side of the cart, which gives you perfect shade. No need to clean and it is much cheaper and faster to replace. 15 years of experience selling hot dogs will tell you that a vinyl umbrella needs to be clean with a brush and soap in an open space once a week from the dust and the grease.
The grill and the steam table on the California Grill hot dog cart run on propane. There are two propane tanks stored neatly and easily-accessible behind a door with a safety latch in its own propane compartment located in the front part of the cart. It holds two twenty-pound tanks, so you will not run out in the middle of the day. Tanks are not included.
The California Grill hot dog cart rests on a D.O.T. approved heavy duty trailer (title available) with baked enamel finished. The leaf spring suspension system allows you to tow it at freeway speeds with safety. The tires size is 4.8” x 8” standard.
The tow bar hitch on the California Grill hot dog cart is removable (great feature, as this looks better and you can walk around the trailer without having to jump over it). It is equipped with a 1 7/8″ ball coupler with two safety chains, and is also available with an optional size 2″ ball coupler.
The lights on the California Grill hot dog cart are tail, stop, signal and hazards. The wiring harness for the lights is male. The lights come with a license plate holder.
WHEEL LEVELING JACK
Keep your California Grill hot dog cart on the level with this easy-to-use 1500 lb. capacity swing-back trailer jack. With the swing-back style there’s no need to remove the jack when hauling the hot dog cart, just fold it back and away. The trailer jack has a side crank handle to level it.
The brochure contains the information need it by Health Departments to pre-approve your hot dog cart and after a physical inspection get you the final approval for the Mobile Food License.
- In this PDF format document you will find:
- • Manufacturer’s information
- • Four photos of the hot dog cart
- • Main features
- • Detailed description
- • Specifications
• Three schematics drawings (upper, right and left views)
- One left-clicked on the link below to open the brochure to print or download it.
You can also copy the link and email it to your health department inspector.California Grill Hot Dog Cart Brochure
Schematics allow you to see the location of all significant parts and equipment and the overall dimensions of the hot dog cart. They are available in three different views (top, left and right). Most Health Departments require them as a part of the Mobile Food License Application. The schematics are also included in the brochure for the hot dog cart.
One left-clicked on the links below to view, print or download them.
2′ Ball coupler w/safety chains $32
24″ Commercial griddle $720
5 Pans condiment table $110
Extra side shelf each $70
2 Electrical outlets 110v $120
LED tail lights $64
Logos CALL FOR PRICING
Napkin dispenser $19
Potato chips clips each $10