California Grill Hot Dog Cart


California Grill Hot Dog Cart


  • –  4 Burner double deck stainless steel grill w/grease tray
  • –  2 Full size steam table w/controls (pans included)
  • –  4 Sinks (wash, rinse, sanitize & hand washing)
  • –  Hot & cold pressurized water (four swivel faucets)
  • –  20 Gallon fresh water tank
  • –  Insulated beverage bin w/drain (144 cans)
  • –  Compact refrigerator with adjustable shelves & interior light
  • –  2 Propane tank enclosed compartment



The stainless steel grill on the California Grill hot dog cart is a double rack four independent burners with plenty of cooking space. The drip tray is below the barbecue and sufficient to hold grease for months, so you won’t have to clean it every day. Please know that people prefer grilled hot dogs and sausages rather than steamed.


The steam table on the California Grill hot dog cart is double and can accommodate various size pots and lids. You can use the steamer for the buns, chili and sauerkraut. You can also steam your hot dogs since the steam table has its own burner and shut off valve. The stainless steel pans and lids (2 spillage pans, 6 1/3 pans and 2 roll tops) are easily removable for cleaning. NSF approved pans and lids.

SINKS (4 total)
SINKS (4 total)

The California Grill hot dog cart has three ware washing sinks with hot and cold water. Each ware washing sink is large enough to accommodate the largest utensil. Ware washing sinks are 12″ wide x 12″ long x 10″ deep. Each ware washing sink has a mixing swivel faucet capable of providing hot water at a minimum of 120 degrees Fahrenheit and cold water at 99 degrees Fahrenheit or less as required by law.

An 8″ high metal splashguard separates the hand washing sink from the other three sinks. The hand washing sink is 12″ wide x 9″ long x 10″ deep. It has the same swivel faucet type as the others.


The water heater has a four gallon capacity and can heat water to a minimum of 90 degrees Fahrenheit.  A water line connects the heater with the fresh water tank.


The California Grill hot dog cart has an electrical water pump capable of delivering a minimum of 1 gallon per minute of hot and cold water.


The 4/5 gallon potable water tanks on the California Grill hot dog cart are sufficient in volume to fulfill the required 5 gallon minimum for hand washing and the 15 gallon for ware washing and food preparation.


Four sink drains connect to the waste water tank on the California Grill hot dog cart with watertight seals. The wastewater tank has an air vent water flow to prevent potential flooding of the interior of the cart. The tank has a capacity of 36 gallons and it has a discharge valve to facilitate complete draining.


The insulated beverage bin on the California Grill hot dog cart is easily reachable for customers to help themselves. It maximizes the life of ice and has its own drain and plug. It holds 144 cans and is easy to refill. The hinged lid has a chrome handle.


The California Grill hot dog cart has an electrical refrigeration unit to store all potentially hazardous foods as required by California law.


There are two storage compartments on the cart. One is in the front and one is in the back.  The storage compartment in the back is the perfect place to keep extra napkins, extra foil, paper bags, straws, tongs, spoons, etc. The storage compartment in the front under the steam table is the place to keep your fresh hot dog buns. Both compartments have a door with a safety latch.


The 9 ft. market umbrellas on the  cart can be the color of your choice. The umbrella holders are at each side of the cart, which gives you perfect shade. Every now and then you can remove the cloth part of the umbrellas and through them in the laundry machine.
Market umbrellas are less expensive and faster to replace than vinyl umbrellas. Vinyl umbrellas are high maintenance because they collect a lot of grease and dust. Therefore, you will have to clean them with soap and a brush at least once a week.


The grill and the steam table on the cart run on propane. Two twenty-pound propane tanks (not included) are located at the front part of the trailer in its own propane compartment. This compartment has an easily-accessible door and a safety latch.


The California Grill hot dog cart rests on a D.O.T. approved heavy duty trailer (title available) with baked enamel finished. The leaf spring suspension system allows you to tow it at freeway speeds with safety. The tires size is 4.8” x 8” standard.


The cart towing bar is removable (great feature, as this looks better and you can walk around the trailer without having to jump over it). The ball coupler is 1 7/8″ an it has two safety chains, and it is also available with an optional 2″ size.


The lights on the California Grill hot dog cart are tail, stop, signal and hazards. The wiring harness for the lights is male. The lights come with a license plate holder.


Keep your California Grill hot dog cart on the level with this easy-to-use 1000 lb. capacity swing-back trailer jack. The jack has a side crank handle to level it. Just fold it back and away for travelling.



The brochure contains the information need it by Health Departments to pre-approve your hot dog cart and after a physical inspection get you the final approval for the Mobile Food License.

    In this PDF format document you will find:
  • • Manufacturer’s information
  • • Four photos of the hot dog cart
  • • Main features
  • • Detailed description
  • • Specifications

    • Three schematics drawings (upper, right and left views)

      One left-clicked on the link below to open the brochure to print or download it. You can also copy the link and email it to your health department inspector.

      California Grill Hot Dog Cart Brochure


Schematics allow you to see the location of all significant parts and equipment and the overall dimensions of the hot dog cart. They are available in three different views (top, left and right). Most Health Departments require them as a part of the Mobile Food License Application. The schematics are also included in the brochure for the hot dog cart.

One left-clicked on the links below to view, print or download them.



12v Refrigerator $975
2′ Ball coupler w/safety chains $32
24″ Commercial griddle $720
5 Pans condiment table $110
Extra side shelf each $70
2 Electrical outlets 110v $120
LED tail lights $64
Napkin dispenser $19
Potato chips clips each $10

Cart Inquiry

Apply for Credit

Applicant Information
If Sole Propietorship, your Fed I.D. or Social Security Number

Applicant Previous Residence
Complete If You've Been At Your Current Residence For Less Than 2 Years

Applicant Employment Information

Applicant Previous Employer
Complete If You've Been At Your Current Employment For Less Than 2 Years

Bank Information

Hot Dog Cart Information

Financing Information

Authorization To Release Information
Credit Authorization: I/We hereby authorize Archer Capital, LLC., its designee, assigns or potential assigns to review his/her personal credit profile provided by national credit bureaus in considering this application and for the purpose of updating, renewing, extending additional credit or the collection of any late account. I/We hereby authorize our references to release all credit information and I/We represent and warrant that the information submitted herein is true, complete and accurate. A facsimile, electronic or other copy of this authorization shall be as valid as the original. By clicking SUBMIT I/We agree to credit authorization.

Related Hot Dog Carts

Close Menu